Product ID:E-57 EMULSIFIER
MSDS Date:01/01/1995
FSC:6850
NIIN:01-268-7122
MSDS Number: BGWGF

Emergency Phone: 310-450-1111/800-424-9300(CHEMTREC)

Info Phone: 310-450-1111

Cage: 98733

Telephone: 310-450-1111/FAX 310452-4046

Cage: 98733

HYDROTREATED MIDDLE PETROLEUM DISTILLATE/PETROLEUM

CAS: 64742-46-7

RTECS: JN9379645

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY
TRACT. ACUTE- MAY CAUSE SLIGHT EYE & SKIN IRRITATION. INHALATION OF
VAPORS/OIL MIST MAY CAUSE MILD UPPER RESPIRATORY TRACT IRRITATION.
INGESTION MAY CAUSE NAUSEA & VOMITING. ASPIRATION HAZARD. CHRONIC-
UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
AND/OR RESPIRATORY DISORDERS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS
OF THIS PRODUCT.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES. HOLD EYELIDS OPEN. SKIN:WIPE OFF EXCESS. WASH SKIN WITH
SOAP & WA TER. ORAL:DO NOT INDUCE VOMITING. IF CONSCIOUS, RINSE
MOUTH. SEEK MEDICAL ATTENTION. IF SPONTANEOUS VOMITING OCCURS,
MONITOR FOR BREATHING DIFFICULTY.

Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM/DRY CHEMICAL.
DO NOT USE DIRECT STREAM OF WATER.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONTAINER MAY BURST. PRODUCT DOES NOT
BURN UNLESS PREHEATED.

Spill Release Procedures:VENTILATE AREA. RECOVER FREE OIL IF POSSIBLE.
ABSORB SPILL WITH INERT MATERIAL SUCH AS SAND, CLAY, EARTH &
SHOVELD INTO CONTAINERS FOR LATER DISPOSAL. PREVENT RUN-OFF TO
ENTER WATERWAYS, SEWERS. ALL R ESPONSE ACTIVITIES MUST COMPLY WITH
HAZWOPER.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE AWAY FROM HEAT, FLAME & STRONG
OXIDANTS. KEEP CONTAINERS CLOSED WHEN NOT IN USE. KEEP OUT OF REACH
OF CHILDREN.
Other Precautions:DO NOT GET IN EYES, ON SKIN OR ON CLOTHING. WASH
THOROUGHLY AFTER HANDLING. AVOID BREATHING OIL MIST. DISCARD
LUBRICANT-SOAKED SHOES. REMOVE LUBRICANT-SOAKED CLOTHING AND
LAUNDER BEFORE RE-USE.

Respiratory Protection:NONE NORMALLY REQUIRED. IF EXPOSURE MAY OR DOES
EXCEED OCCUPATIONAL EXPOSURE LIMITS, WEAR A NIOSH-APPROVED ORGANIC
VAPOR RESPIRATOR.
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS OF THIS MATERIAL
BELOW APPLICABLE STANDARD(S).
Protective Gloves:NITRILE OR NEOPRENE RECOMMENDED
Eye Protection:SAFETY GLASSES, FACE SHIELD RECOMMENDED
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health

HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:400F,204C
Melt/Freeze Pt:M.P/F.P Text:-75F,-59C
Spec Gravity:0.92
Solubility in Water:EMULSIFIABLE
Appearance and Odor:PINK OILY LIQUID; SLIGHT HYDROCARBON ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, OPEN FLAME
Hazardous Decomposition Products:MAY PRODUCE SMOKE, CARBON MONOXIDE,
CARBON DIOXIDE AND OTHER DECOMPOSITION PRODUCTS.

Waste Disposal Methods:DISPOSE OF WASTE IN COMPLIANCE WITH ALL
APPLICABLE LOCAL, STATE AND FEDERAL LAWS AND REGULATIONS. RCRA
EMERGENCY NUMBER: 800-424-9346. DO NOT CONTAMINATE ANY LAKES,
STREAMS, PONDS OR UNDERGROUND WATER SUPPLY. INCINERATION IS
RECOMMENDED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.